PS Magazine category graphic
JLTV A1 FOV: Inspect Tow Eyes for Cracks NOW!
By | March 8, 2024
According to TACOM SOUM 23-002, cracks have been found on the front tow eyes of some JLTV A1s and the cracks could cause the tow eyes to fail. A tow eye failure could potentially cause a fatal accident. Get more info here...

PS Magazine category graphic
JLTV AO/A1: DSDU Supply Turn-in Procedures
By | Aug. 15, 2023
If you have JLTVs, you’ll want to read supply advisory message (SAM) 23-001 for detailed turn-in guidance for the driver smart display unit (DSDU). See more...

PS Magazine category graphic
JLTV: Transmission Fluid NSNs
By | April 5, 2023
Only use TES-295 transmission fluid in your JLTV and don’t mix other fluids. We’ve got NSNs for the correct transmission fluid here...

PS Magazine category graphic
JLTV: Updated Battery Disconnect Procedure
By | April 4, 2023
TACOM MIM 23-010 updates the current battery disconnect/connect WP M06000 in TM 9-2320-452-23&P (Feb 19). Here’s what you need to know...

PS Magazine category graphic
JLTV: Updated PMCS Intervals for Brake Fluid Replacement
By | Dec. 8, 2022
You’ll need to replace your JLTV’s brake fluid if it’s aged two (2) years or more because PMCS brake fluid replacement intervals have been updated. Get the info here…...

PS Magazine category graphic
JLTV: Flat Towing Procedures
By | Nov. 28, 2022
According to GSAM 22-016, several JLTV towing incidents warrant an update to WP 0080 that adjusts the suspension height of the recovery vehicle. Here’s what you need to know…...

PS Magazine category graphic
JLTV: Visit UTAP for Additional Vehicle Training Info
By | Nov. 14, 2022
If you’re looking for additional training material, lesson plans, schematics and more for the JLTV, just visit UTAP. Read about it here…...

Ground Vehicles V2 Category Graphic
Ground Vehicles: Drive Like Your Life Depends on It!
By | June 10, 2022
Warfighters, MSG Half-Mast requests you huddle up with your fellow Soldiers and remind them that driving tactical vehicles is serious business. Just how serious is it? Find out here...

Category graphic for 2021 year-in-review articles.
Tactical Vehicles: 2021 Year-in-Review
By | Jan. 21, 2022
Maintenance leaders, NSNs were the most frequent topics covered in 2021 for tactical vehicles and trailers. Corrosion prevention and the roll-out of Non-Combat Operations Maintenance Plan (NCOMP) were also hot topics this...

PS Magazine category graphic
JLTV: Update MSD for Best Performance
By | Jan. 19, 2022
Warfighters, when it comes to the maintenance support device (MSD) for your JLTV, you’ll want to make sure it has the latest software and firmware versions. Here's the scoop...

PS Magazine category graphic
JLTV: Front-Rear Differential NSN Updates
By | Oct. 29, 2021
If you didn’t see the JLTV LARSALL message from 19 Feb 21, make a note that the NSNs for the front differential assembly shown as Item 1 of Fig 248 and the rear differential (transaxle) shown as Item 1 of Fig 256 in TM...

PS Magazine category graphic
JLTV: A/C Lines and Radiator Tube Interference
By | Aug. 17, 2021
Some fielded A1-series JLTVs have been found with coolant tubes contacting the A/C line fitting on the coolant hose assembly. The primary causes are line routing and their close proximity to each other. Vibrations during...

PS Magazine category graphic
JLTV: Avoid High-Pressure Water Damage
By | July 12, 2021
JLTVs have state-of-the-art equipment and electrical components that require special care whenever you clean the trucks. So be careful when washing the truck, especially the engine compartment. High-pressure water can damage...

PS Magazine category graphic
JLTV: Training Videos for Operators and Maintainers
By | Oct. 13, 2020
Does your unit have Joint Light Tactical Vehicles (JLTVs)? Videos offering refresher training on critical tasks for both operators and maintainers are in the works. The first few videos, such as Brake Caging Operations,...

PS Magazine category graphic
JLTV: Disconnect AFES Before Maintenance
By | Aug. 11, 2020
If you operate or maintain a Joint Light Tactical Vehicle (JLTV), be aware that the automatic fire extinguishing system (AFES) can accidentally discharge during vehicle maintenance. There are even reports of Soldiers being...

PS Magazine category graphic
JLTV: Door Hazard Requires Caution
By | May 7, 2020
Soldiers are understandably excited to use the new Joint Light Tactical Vehicle (JLTV), the Army’s replacement for the HMMWV. But don’t let the excitement cloud this caution: use the handhold bar, not the B-pillar, when...