MRAP-MATV

By | Aug. 14, 2023

TACOM has noticed that shock bushings, also known as resilient mounts, aren’t being serviced during PMCS on MATVs. Here’s what operators and mechanics need to know...

MRAP: Troubleshooting 10-Amp Fuse Could Solve Problems

By | March 29, 2023

In the current troubleshooting steps in the MRAP TMs, a step is missing to check a 10-AMP fuse. If you don’t check the fuse on the C51 connector, it can lead to costly and time-consuming troubleshooting efforts. Read all...

M-ATV MRAP: Think Twice Before Scrapping Shocks

By | March 6, 2023

Damaged or leaky shock absorbers on your M-ATV MRAP make the vehicle NMC. However, not all condensation is a leak, so carefully evaluate the situation before replacing any shock absorber. Keep reading for all the details...

M-ATV FOV: New Inspections Prevent Damaged NATO Cables

By | Oct. 25, 2022

According to TACOM MA message 23-001, you need to inspect your M-ATV’s hood attachments and NATO cables. There’s an inspection document with details for inspecting hood brackets, hard stops and quick edge you must use until...

MRAP, M-ATV: Add Reflective Tape for Safety’s Sake

By | Sept. 20, 2022

MRAP and M-ATV door handles and escape latches are hard to see, so illuminate them by adding strips of reflective tape. Here’s how to get the tape and where to apply it…...

MRAP, M-ATV: Service Kit NSNs

By | Aug. 16, 2022

Service kits for MRAPs and M-ATVs are essential for keeping these vehicles mission-ready. Read on to get the NSNs...

Ground Vehicles: Drive Like Your Life Depends on It!

By | June 10, 2022

Warfighters, MSG Half-Mast requests you huddle up with your fellow Soldiers and remind them that driving tactical vehicles is serious business. Just how serious is it? Find out here...

MRAP: Rev-up MaxxPros with Particle Separator Cleaning

By | April 22, 2022

Operators, a few years ago in TACOM Maintenance Action Message (MAM) 19-012, TACOM evaluated the particle separator used on all three (3) models of the MaxxPro and decided that annual replacement was no longer necessary...

Corrosion: Bust Rust with TACOM CCI Checklists

By | March 31, 2022

Maintenance leaders, did you know the TACOM Corrosion website has corrosion control inspection (CCI) checklists? It sure does. Here's what you need to know...

Tactical Vehicles: Don’t Make Winter Driving a Chilling Experience

By | Feb. 28, 2022

Operators, winter driving presents unique challenges. The bottom line is that you need to be prepared for these challenges. Here's what you need to know...

MRAP: Learn Your Rollover Lesson

By | Jan. 21, 2022

This article initially appeared in PS 771 (Feb 17), p. 11. Operators, it’s always better to avoid a rollover than to experience one. Remember these lessons learned before you start the day’s mission. Get the lessons here...

MRAP M-ATV: PM for Hard Steering

By | Oct. 28, 2020

Operators, it’s hard to turn the M-ATV’s steering wheel, especially when the vehicle has been sitting for a while. That’s because wet sand and mud corrode the steering wheel shaft where it mounts into the cab’s floor. Here’s...

MRAP, M-ATV: NSN for Air Dryer

By | Oct. 28, 2020

Dear Half-Mast, we’re having some problems ordering an air dryer for our M-ATVs. We could sure use a good NSN for this part. Can you please help? Don’t worry! I got you covered. Read on to get the information you need...

M-ATV/MRAP: Better Check Your Optima® Batteries

By | Sept. 30, 2020

Does your unit’s MRAPs include M-ATVs? Heads up! You’re no longer able to order the Optima® REDTOP® battery, NSN 6140-01-534-6466, according to TACOM LCMC Maintenance Information Message (MIM) 20-040...